冷再生施工和機械租賃業務
築路架橋•✘,奉獻社會;以人為本•✘,追求卓越

服務熱線

18264104888

新聞中心

首頁>>新聞中心>>講解水泥就地冷再生技術詳解

講解水泥就地冷再生技術詳解

來源✘✘│:http://www.soundaffectsdc.com/ 日期✘✘│:2022-07-30 釋出人✘✘│:guanli
經過多年的推廣•✘,水泥就地冷再生技術被業內人士所熟知•✘,並經常加以應用•✘,看似簡單的水泥就地冷再生工藝•✘,對於質量把握方面實際並不簡單•✘,理由如下✘✘│:
After years of promotion, the cement in situ cold regeneration technology is well known by people in the industry and is often applied. The seemingly simple cement in situ cold regeneration process is not simple in terms of quality assurance. The reasons are as follows:
1◕│·、冷再生工藝有其適用性•✘,先期路面診斷很必要▩☁☁₪。水泥就地冷再生工藝一般是對原路面進行銑刨◕│·、整平◕│·、碾壓再成層的施工技術•✘,他只是對於淺層(不大於25cm)路面結構的再生利用•✘,所以對於路面結構下層的病害沒有修復作用▩☁☁₪。對於路面基層承載力不足•✘,彎沉值過大等情況需要進行深層處理以恢復路面的使用功能•✘,簡單的一層冷再生工藝不能起到長效的效果▩☁☁₪。
1. The cold regeneration process has its applicability, so it is necessary to diagnose the pavement in advance. The cement in situ cold recycling process is generally the construction technology of milling, leveling, rolling and re layering the original pavement. It is only the recycling of the shallow (no more than 25cm) pavement structure, so it has no repair effect on the diseases of the lower layer of the pavement structure. For the insufficient bearing capacity of the pavement base and the excessive deflection value, deep treatment is needed to restore the use function of the pavement, and the simple one-layer cold regeneration process cannot have a long-term effect.
2◕│·、冷再生層級配的檢測與調整會影響到再生層的質量▩☁☁₪。冷再生層根據原有路面的結構有灰土基層的冷再生◕│·、二灰碎石基層冷再生與水穩碎石基層冷再生▩☁☁₪。對於灰土基層的冷再生一定要慎重•✘,建議只當路面底基層使用▩☁☁₪。相同水泥劑量情況下•✘,路面基層級配合適與否直接影響其強度•✘,所以經篩分不滿足級配要求的銑刨料須新增新料進行調整▩☁☁₪。
2. The detection and adjustment of the cold regeneration layer configuration will affect the quality of the regeneration layer. According to the structure of the original pavement, the cold regeneration layer includes the cold regeneration of lime soil base, lime fly ash macadam base and water stabilized macadam base. We must be careful about the cold regeneration of lime soil base, and it is recommended to use it only for the subbase of the pavement. Under the condition of the same cement dosage, whether the gradation of pavement base is appropriate or not directly affects its strength, so the milled materials that do not meet the gradation requirements after screening must be adjusted by adding new materials.
3◕│·、水泥劑量的確定也會直接影響到再生層的質量▩☁☁₪。適宜的水泥劑量不僅可以避免因水泥劑量不足而導致的強度不足現象•✘,而且可以減少因水泥劑量過大而造成的基層應力收縮裂縫現象•✘,延長道路的壽命▩☁☁₪。
3. The determination of cement dosage will also directly affect the quality of regeneration layer. Appropriate cement dosage can not only avoid the phenomenon of insufficient strength caused by insufficient cement dosage, but also reduce the phenomenon of stress shrinkage cracks caused by excessive cement dosage and prolong the service life of the road.
冷再生機租賃
4◕│·、水泥的選用至關重要▩☁☁₪。水泥冷再生並不是使用任何水泥都可以•✘,它有嚴格的要求▩☁☁₪。它對水泥結合料的要求基本與水泥穩定碎石對水泥的要求相同•✘,需要初凝時間大於3小時•✘,終凝時間大於6小時的緩凝水泥▩☁☁₪。
4. The selection of cement is very important. Cold recycling of cement is not possible with any cement. It has strict requirements. Its requirements for cement binder are basically the same as those for cement stabilized macadam, requiring retarded cement with initial setting time of more than 3 hours and final setting time of more than 6 hours.
5◕│·、施工用水的選擇▩☁☁₪。看似無關緊要的因素•✘,但可能因使用雜質過多或鹽離子過多的施工用水•✘,致使工程質量出現問題▩☁☁₪。
5. Selection of construction water. Seemingly insignificant factors, but there may be problems in the project quality due to the use of excessive impurities or salt ions.
6◕│·、冷再生機租賃人員認為水泥攤鋪的均勻程度直接影響強度的均勻性▩☁☁₪。
6. The leasing personnel of the cold recycling machine believe that the uniformity of cement paving directly affects the uniformity of strength.
7◕│·、合理的整平時機會影響再生層的內在質量▩☁☁₪。一般再生機自重都較重•✘,再生後兩輪間與輪跡處密實度會存在很大的差異性•✘,如何消除此間差異性後再刮平直接會影響到再生層內部密實度的均勻性▩☁☁₪。
7. Reasonable leveling will affect the internal quality of the regeneration layer. Generally, the self weight of the regenerator is heavy, and there will be great differences in the compactness between the two wheels and the wheel trace after regeneration. How to eliminate this difference and then scrape it will directly affect the uniformity of the compactness inside the regeneration layer.
水泥冷再生施工工藝做好並不容易•✘,並不是任何一個施工隊伍都能夠嚴格把控的•✘,所以在施工過程選用專業•✘,規範的作業隊伍是保障工程質量的前提▩☁☁₪。更多相關資訊獲取就來我們網站http://www.soundaffectsdc.com看看吧▩☁☁₪。
It is not easy to do a good job in the construction process of cement cold recycling, and not any construction team can strictly control it. Therefore, the selection of professional and standardized operation teams in the construction process is the premise to ensure the project quality. Come to our website for more information http://www.soundaffectsdc.com Take a look.

推薦閱讀/ Recommended reading

天氣清冷之前•✘,機械該如何進行保養呢☁↟╃?冷再生機出租廠家這裡為您簡單的講一講▩☁☁₪。How to maintain the machinery before the cold we

租賃廠家對冷再生機維護的方法 2022-09-30
冷再生機租賃選擇以及維護問題 2022-09-28
為什麼利用冷再生機施工☁↟╃? 2022-09-24
道路上使用冷再生機有哪些優點 2022-09-23

推薦產品/ Recommended products

极品白嫩的小少妇,高h 重口 激h 慎宫交h,怡红院院,美女网站视频